PDF下載
[1]李義爍,梁遠,顏瑩瑩,等.餐廚垃圾/市政污泥/城市糞便聯合厭氧消化沼液處理設計[J].中國給水排水,2021,37(14):56-62.
LI Yi-shuo,LIANG Yuan,YAN Ying-ying,et al.Design of Treatment Process of Biogas Slurry from Anaerobic Co-digestion of Kitchen Waste/Municipal Sludge/Urban Excrement[J].China Water & Wastewater,2021,37(14):56-62.點擊復制
餐廚垃圾/市政污泥/城市糞便聯合厭氧消化沼液處理設計
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第37卷 期數: 2021年第14期 頁碼: 56-62 欄目: 出版日期: 2021-07-17
Title:Design of Treatment Process of Biogas Slurry from Anaerobic Co-digestion of Kitchen Waste/Municipal Sludge/Urban Excrement
作者:李義爍，梁遠，顏瑩瑩，胡嘯，李雪怡，劉迪，馬嘉蔚(北京首創污泥處置技術有限公司，北京100044)
Author(s):LI Yi-shuo，LIANG Yuan，YAN Ying-ying，HU Xiao，LI Xue-yi，LIU Di，MA Jia-wei(Beijing Capital Sludge Disposal Co. Ltd., Beijing 100044， China)
關鍵詞:餐廚垃圾; 市政污泥; 城市糞便; 聯合厭氧消化; MBR; NF; 中溫催化氧化
Keywords:kitchen waste; municipal sludge; urban excrement; anaerobic co-digestion; MBR; NF; mesophilic catalytic oxidation
摘要:針對北京某有機質生態處理站餐廚垃圾、市政污泥、城市糞便聯合厭氧消化產生的沼液等綜合廢水特點，采用生物+物化組合工藝，即：預處理+外置式膜生物反應器（MBR，兩級硝化反硝化+超濾）+部分納濾（NF）處理工藝，納濾產生的濃縮液采用中溫催化氧化工藝進行處理，最終實現廢水達標排放。該工程設計處理規模為700 m3/d，工程運行結果表明,該工藝運行穩定、效果良好，綜合出水水質達到《污水綜合排放標準》（GB 8978—1996）中的三級標準，其中氨氮和總氮指標達到北京市地方標準《水污染物綜合排放標準》（DB 11/307—2013）。
Abstract:Based on analyzing characteristics of biogas slurry water quality from anaerobic co-digestion of kitchen waste, municipal sludge and urban excrement in an organic ecological treatment station in Beijing, a biological and physicochemical combination process was employed, which consisted of pretreatment, external membrane bioreactor (MBR, two-stage nitrification/denitrification and ultrafiltration) and partial nanofiltration (NF). Concentrate produced by the nanofiltration was treated by mesophilic catalytic oxidation process, and the effluent quality could finally reach the discharge standard. The designed treatment capacity of this project was 700 m3/d. The operational results indicated that the process was stable and had a good performance. The comprehensive effluent quality reached the third level limitations of Integrated Wastewater Discharge Standard (GB 8978-1996), among which ammonia nitrogen and total nitrogen met the limitations of the Beijing local standard Integrated Discharge Standard of Water Pollutants (DB 11/307-2013).
相似文獻/References:
[1]劉常青,陳琬,曾藝芳,等.SARD與CSTR反應器半連續發酵產氫能力對比[J].中國給水排水,2018,34(21):7.
LIU Chang qing,CHEN Wan,ZENG Yi fang,et al.Hydrogen Production Capacity of Semi continuous Fermentation of SARD and CSTR Bio hydrogen Production Reactor[J].China Water & Wastewater,2018,34(14):7.
[2]魯濤,朱寶飛,石春梅,等.污泥碳化系統試運行及污泥炭回歸土壤可行性分析[J].中國給水排水,2018,34(21):108.
LU Tao,ZHU Bao fei,SHI Chun mei,et al.Test Run of Sewage Sludge Carbonization System and Feasibility Analysis of Sludge Carbon Land Use[J].China Water & Wastewater,2018,34(14):108.
[3]李慧莉,何芙蓉,劉鵬程,等.外源酶強化秸稈污泥混合厭氧消化條件優化[J].中國給水排水,2020,36(15):6.
LI Hui-li,HE Fu-rong,LIU Peng-cheng,et al.Optimization of Anaerobic Co-digestion Conditions of Straw and Sludge Enhanced by Exogenous Enzymes[J].China Water & Wastewater,2020,36(14):6.
[4]孫建升,葉雅麗,鄭興燦,等.昆明市污水處理廠污泥處理工藝的研究與探討[J].中國給水排水,2020,36(18):108.
SUN Jian-sheng,YE Ya-li,ZHENG Xing-can,et al.Research and Discussion on the Sludge Disposal Technology of Kunming WWTPs[J].China Water & Wastewater,2020,36(14):108.
[5]夏一帆,王冰潔,涂凌波,等.DMBR短程硝化反硝化處理餐廚垃圾厭氧沼液[J].中國給水排水,2021,37(7):27.
XIA Yi-fan,WANG Bing-jie,TU Ling-bo,et al.Treatment of Food Waste Digestate by DMBR with Partial Nitrification and Denitrification[J].China Water & Wastewater,2021,37(14):27.
[6]張會文,代曉炫,姜偉,等.市政污泥的水熱反應減量化及水分賦存形態研究[J].中國給水排水,2021,37(7):96.
ZHANG Hui-wen,DAI Xiao-xuan,JIANG Wei,et al.Reduction and Water Forms of Municipal Sludge Treated by Hydrothermal Reaction[J].China Water & Wastewater,2021,37(14):96.
[7]王華金.餐廚垃圾全物料濕式厭氧消化產沼技術的工程應用[J].中國給水排水,2021,37(8):95.
WANG Hua-jin.Engineering Application of Wet Anaerobic Digestion and Biogas Production Technology for Full-scale Food Waste[J].China Water & Wastewater,2021,37(14):95.
[8]呂開雷,楊淘,陳紫君,等.電解鋁煙氣余熱低溫干化處理市政污泥工程應用[J].中國給水排水,2021,37(12):120.
Lü Kai-lei,YANG Tao,CHEN Zi-jun,et al.Application of Low Temperature Drying in Municipal Sludge Treatment with Waste Heat of Electrolytic Aluminum Flue Gas[J].China Water & Wastewater,2021,37(14):120.
[9]李彪,周欣,高波,等.順義區污泥干化焚燒處理工程工藝設計[J].中國給水排水,2021,37(14):63.
LI Biao,ZHOU Xin,GAO Bo,et al.Design of Sludge Drying Incineration Treatment Process in Shunyi District[J].China Water & Wastewater,2021,37(14):63.
[10]李月中,譚婧,宮亞斌,等.中高溫過渡區餐廚垃圾厭氧工程案例分析[J].中國給水排水,2021,37(20):106.
LI Yue-zhong,TAN Jing,GONG Ya-bin,et al.Case Study of a Food Waste Anaerobic Digestion Biogas Project at Mesophilic and Thermophilic Temperature[J].China Water & Wastewater,2021,37(14):106.
更新日期/Last Update: 2021-07-19
[1]李義爍,梁遠,顏瑩瑩,等.餐廚垃圾/市政污泥/城市糞便聯合厭氧消化沼液處理設計[J].中國給水排水,2021,37(14):56-62.
LI Yi-shuo,LIANG Yuan,YAN Ying-ying,et al.Design of Treatment Process of Biogas Slurry from Anaerobic Co-digestion of Kitchen Waste/Municipal Sludge/Urban Excrement[J].China Water & Wastewater,2021,37(14):56-62.
點擊復制
餐廚垃圾/市政污泥/城市糞便聯合厭氧消化沼液處理設計
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第37卷 期數: 2021年第14期 頁碼: 56-62 欄目: 出版日期: 2021-07-17
- Title:
- Design of Treatment Process of Biogas Slurry from Anaerobic Co-digestion of Kitchen Waste/Municipal Sludge/Urban Excrement
- 作者:
- 李義爍，梁遠，顏瑩瑩，胡嘯，李雪怡，劉迪，馬嘉蔚
- (北京首創污泥處置技術有限公司，北京100044)
- Author(s):
- LI Yi-shuo，LIANG Yuan，YAN Ying-ying，HU Xiao，LI Xue-yi，LIU Di，MA Jia-wei
- (Beijing Capital Sludge Disposal Co. Ltd., Beijing 100044， China)
- 關鍵詞:
- 餐廚垃圾; 市政污泥; 城市糞便; 聯合厭氧消化; MBR; NF; 中溫催化氧化
- Keywords:
- kitchen waste; municipal sludge; urban excrement; anaerobic co-digestion; MBR; NF; mesophilic catalytic oxidation
- 摘要:
- 針對北京某有機質生態處理站餐廚垃圾、市政污泥、城市糞便聯合厭氧消化產生的沼液等綜合廢水特點，采用生物+物化組合工藝，即：預處理+外置式膜生物反應器（MBR，兩級硝化反硝化+超濾）+部分納濾（NF）處理工藝，納濾產生的濃縮液采用中溫催化氧化工藝進行處理，最終實現廢水達標排放。該工程設計處理規模為700 m3/d，工程運行結果表明,該工藝運行穩定、效果良好，綜合出水水質達到《污水綜合排放標準》（GB 8978—1996）中的三級標準，其中氨氮和總氮指標達到北京市地方標準《水污染物綜合排放標準》（DB 11/307—2013）。
- Abstract:
- Based on analyzing characteristics of biogas slurry water quality from anaerobic co-digestion of kitchen waste, municipal sludge and urban excrement in an organic ecological treatment station in Beijing, a biological and physicochemical combination process was employed, which consisted of pretreatment, external membrane bioreactor (MBR, two-stage nitrification/denitrification and ultrafiltration) and partial nanofiltration (NF). Concentrate produced by the nanofiltration was treated by mesophilic catalytic oxidation process, and the effluent quality could finally reach the discharge standard. The designed treatment capacity of this project was 700 m3/d. The operational results indicated that the process was stable and had a good performance. The comprehensive effluent quality reached the third level limitations of Integrated Wastewater Discharge Standard (GB 8978-1996), among which ammonia nitrogen and total nitrogen met the limitations of the Beijing local standard Integrated Discharge Standard of Water Pollutants (DB 11/307-2013).
相似文獻/References:
[1]劉常青,陳琬,曾藝芳,等.SARD與CSTR反應器半連續發酵產氫能力對比[J].中國給水排水,2018,34(21):7.
LIU Chang qing,CHEN Wan,ZENG Yi fang,et al.Hydrogen Production Capacity of Semi continuous Fermentation of SARD and CSTR Bio hydrogen Production Reactor[J].China Water & Wastewater,2018,34(14):7.
[2]魯濤,朱寶飛,石春梅,等.污泥碳化系統試運行及污泥炭回歸土壤可行性分析[J].中國給水排水,2018,34(21):108.
LU Tao,ZHU Bao fei,SHI Chun mei,et al.Test Run of Sewage Sludge Carbonization System and Feasibility Analysis of Sludge Carbon Land Use[J].China Water & Wastewater,2018,34(14):108.
[3]李慧莉,何芙蓉,劉鵬程,等.外源酶強化秸稈污泥混合厭氧消化條件優化[J].中國給水排水,2020,36(15):6.
LI Hui-li,HE Fu-rong,LIU Peng-cheng,et al.Optimization of Anaerobic Co-digestion Conditions of Straw and Sludge Enhanced by Exogenous Enzymes[J].China Water & Wastewater,2020,36(14):6.
[4]孫建升,葉雅麗,鄭興燦,等.昆明市污水處理廠污泥處理工藝的研究與探討[J].中國給水排水,2020,36(18):108.
SUN Jian-sheng,YE Ya-li,ZHENG Xing-can,et al.Research and Discussion on the Sludge Disposal Technology of Kunming WWTPs[J].China Water & Wastewater,2020,36(14):108.
[5]夏一帆,王冰潔,涂凌波,等.DMBR短程硝化反硝化處理餐廚垃圾厭氧沼液[J].中國給水排水,2021,37(7):27.
XIA Yi-fan,WANG Bing-jie,TU Ling-bo,et al.Treatment of Food Waste Digestate by DMBR with Partial Nitrification and Denitrification[J].China Water & Wastewater,2021,37(14):27.
[6]張會文,代曉炫,姜偉,等.市政污泥的水熱反應減量化及水分賦存形態研究[J].中國給水排水,2021,37(7):96.
ZHANG Hui-wen,DAI Xiao-xuan,JIANG Wei,et al.Reduction and Water Forms of Municipal Sludge Treated by Hydrothermal Reaction[J].China Water & Wastewater,2021,37(14):96.
[7]王華金.餐廚垃圾全物料濕式厭氧消化產沼技術的工程應用[J].中國給水排水,2021,37(8):95.
WANG Hua-jin.Engineering Application of Wet Anaerobic Digestion and Biogas Production Technology for Full-scale Food Waste[J].China Water & Wastewater,2021,37(14):95.
[8]呂開雷,楊淘,陳紫君,等.電解鋁煙氣余熱低溫干化處理市政污泥工程應用[J].中國給水排水,2021,37(12):120.
Lü Kai-lei,YANG Tao,CHEN Zi-jun,et al.Application of Low Temperature Drying in Municipal Sludge Treatment with Waste Heat of Electrolytic Aluminum Flue Gas[J].China Water & Wastewater,2021,37(14):120.
[9]李彪,周欣,高波,等.順義區污泥干化焚燒處理工程工藝設計[J].中國給水排水,2021,37(14):63.
LI Biao,ZHOU Xin,GAO Bo,et al.Design of Sludge Drying Incineration Treatment Process in Shunyi District[J].China Water & Wastewater,2021,37(14):63.
[10]李月中,譚婧,宮亞斌,等.中高溫過渡區餐廚垃圾厭氧工程案例分析[J].中國給水排水,2021,37(20):106.
LI Yue-zhong,TAN Jing,GONG Ya-bin,et al.Case Study of a Food Waste Anaerobic Digestion Biogas Project at Mesophilic and Thermophilic Temperature[J].China Water & Wastewater,2021,37(14):106.
更新日期/Last Update: 2021-07-19
